GLYCERIN/PHTHALIC ACID COPOLYMER and PHTHALIC ALKYD RESIN. US2991259A US762935A US76293558A US2991259A US 2991259 A US2991259 A US 2991259A US 762935 A US762935 A US 762935A US 76293558 A US76293558 A US 76293558A US 2991259 A US2991259 A US 2991259A Authority US … As Indian industries are producing paint of amount approximately Rs.15000 crores which needs Alkyd Resin of amount near about Rs. These resins are useful as film forming agents in paint, varnished and enamels & as thermosetting plastics that can be moulded into solid objects. Preparation of alkyd resins Six different alkyds were prepared with RSO, MERSO, glycerol, phthalic anhydride using lead (II) oxide as catalyst using the formula in Table 1. Developmental & Reproductive Toxicity . Cancer: Ingredients linked to cancer in government, industry or academic studies or assessments. Products. Oil-modified alkyd resins constitute a major group of resins used as binders in the coatings industry and is esti-mated that alkyd resins contribute about 70% to the con-ventional binders being used in the surface coating (Bajpai and Seth 2000). There are 92 suppliers who sells phthalic alkyd resine on Alibaba.com, mainly located in Asia. Alkyd resin3231,For the preparation of fast-drying amino baking_OKCHEM. The prepared alkyd resins were copolymerized with styrene using benzyol peroxide as an initiator at 150°C for 3 hr. A tung oil-based acrylated-alkyd resin was synthesized from tung oil, phthalic anhydride, and isobornyl acrylate (IBOA) via an alcoholysis, polyesterification and Diels–Alder reaction with different molar ratios of tung oil and IBOA. An alkyd modified with benzoic acid (RA-BA) was also prepared for comparison. The characteristics of the resin were: acid number = 15 mg KOH/g; viscosity at 23 °C = 5000 mPa s; density = 1.067 g/cm3. The prepared resins are cured by using methyl-ethyl ketone peroxide (MEKP) as initiator and Co-octoate as an accelerator at 120 °C. Qualitative analysis of carboxylic acids in alkyd resins by gas chromatography 428 8. A typical example [74] involves the preparation of an alkyd resin from phthalic anhydride (712 gm), trimethylolpropane (399 gm), isodecyl alcohol (277 gm), and xylene (22 gm) and heating (190°-280°C) to remove water azeotropically and give a resin of acid value 23. You can also choose from appliance paint, car paint, and electrical insulating varnish phthalic alkyd resine, as well as from liquid coating phthalic alkyd resine, and whether phthalic alkyd resine is synthetic resin and plastics. Saturated fatty acid yields non-dyeing or plasticizing resin while drying properties are conferred by unsaturated acids. The solvent system showed a clear single phase solution and a clear coat of binder. FTIR The principal types of polyol used in alkyd synthesis are pentaerythritol, glycerol, trimethylolpropane, trimethylolethane, ethylene glycol, and neopentyl glycol. Mono basic fatty acid or Triglyceride. Varnishes were prepared using these resins and characterized as per standard methods. The following is an excerpt from Kenneth B. Tator's Alkyd Resins article featured in ASM Handbook, Volume 5B: Protective Organic Coatings.The full article also includes an in-depth look at the chemistry, drying oils, drying reactions, production, coating formulations, driers, solvents, oil content, modification and commercial products related to alkyd resins. Phthalic anhydride is a precursor for various industrial products such as plasticizers, alkyd resins & coatings, polyester resins, polyester polyols, and others. % of saturated fatty acids, produced by “Helios” (Domzale, Slovenia), was used as a 70 % solution in methoxypropyl acetate. In this study, commercial alkyd resins were blended with various proportions of phthalic anhydride and oil on solid. The resulting oils are used in alkyd resin preparations or as additives for coatings. prepared using phthalic anhydride, maleic anhydride, and glycerol at stipulated ratios. Preparation of alkyd resins involving the acidolysis of triglyceride oils, isophthalic and terephthalic acids Download PDF Info Publication number US2991259A. Cancer . Identification of type of alkyd resin by infrared spectroscopy 425 7. Thus, the viability of preparing alkyd resin from inedible, non-drying gmelina seed oil (GSO) was investigated. The product is diluted with a 4 : 1 xylene : butyl alcohol mixture to 7 5 % solids. WSCF and WIF were used for preparation of the alkyd resins. 3000 crores. Soybean oil-based alkyd resin was prepared using soy-based polyol, maleic anhydride and phthalic anhydride. Poly basic organic acid – (i.e) Phthalic anhydride 2. 1. MONTH & YEAR OF PREPARATION : February, 2012. Three long oil alkyd resins were prepared from phthalic anhydride (PA) (reference alkyd resin) or depolymerization product of the waste PET (PET-based alkyd resin), glycerin (G), sunflower oil fatty acids (SOFA) and glycol (EG) (reference alkyd resin) or depolymerization product of the waste PET (PET-based alkyd resin). Three different alkyd resins have been developed from Jatropha Curcas oil by varying the amount of phthalic and maleic anhydride. – (i.e)Soya fatty acid The fatty acid profiles of the raw oil were determined with GC-MS. Abstract: In this study, the synthesis, characterization, and properties of a short oil length chain–stopped(rapid) alkyd resin is investigated. Alkyd resins were cheap and can perform good properties depend on the modification. Got it. Most commonly used dibasic acid in alkyd synthesis is Phthalic anhydride while glycerols, Pentaerythritol, trimethylol propane, glycols etc. Phthalic anhydride content 421 5. 5-Chloro-2,3-difluoropyridine White Carbon Silica phenolic resin … PREPARED BY : MSME ... Alkyd resin, which is used in the production of a wide variety of paints, is supplied to the Indian market both from domestic production and import. Products; Suppliers; Hot Search. The principal polybasic acids used in alkyd preparation include phthalic anhydride, isophthalic acid, maleic anhydride, and fumaric acid, among others. A typical example [84] involves the preparation of an alkyd resin from phthalic anhydride (712 gm), trimethylolpropane (399 gm), isodecyl alcohol (277 gm), and xylene (22 gm) and heating (190°-280°C) to remove water azeotropically and give a resin of acid value 23. The phases of the preparation of the modified alkyd resin with maleic and phthalic anhydrides are relised according to the table 2. New alkyd resins were synthesized by reacting (sunflower oil or linoleic acid with poly ethylene glycol or triethanol amine and phthalic anhydride) in the presence of lead oxide as a catalyst. Usually unsaturated dibasic acids such as maleic and fumaric acid are avoided since their use can lead to gelation of the alkyd resin preparation mixture. The physico-chemical properties (viscosity, iodine value, specific gravity, refractive index and acid value) of the GSO were determined and then, it was neutralized, epoxidized, hydroxylated and dehydrated. Linseed oil fatty acid (LFA), used in the preparation of the alkyd resins, was kindly supplied by Croda GmbH, Nettetal, Germany. Polyhydric alcohol – (i.e) Glycerin 3. The principal polybasic acids used in alkyd preparation include phthalic anhydride, isophthalic acid, maleic anhydride, and fumaric acid, among many others. Alkyd resins are used in solvent-based paints. Determination of Mixed Phthalic Acid Isomers in Alkyd Resins. A number in parentheses indicates the year of last reapproval. These resins were characterized for the physical and electrical properties. Alkyd Synthesis, Processing & Manufacturing with Mono Basic Fatty Acid (Soya Fatty Acid) Three major categories of chemical intermediates are utilized in the manufacture of alkyd resin. 4. are used as fatty acid determines the dyeing characteristics of the alkyd resin. Gum rosin modified alkyd resin (RA-GR) was prepared using soybean oil, phthalic anhydride, glycerin and gum rosin acid. Derivatives of phthalic anhydride are used in a broad spectrum of industries such as paints & coatings, automotive, electronics, electrical, building & construction, and other. Phthalic Anhydride Content of Alkyd Resins and Resin Solutions1 This standard is issued under the fixed designation D 563; the number immediately following the designation indicates the year of original adoption or, in the case of revision, the year of last revision. Fatty acids content 422 6. These paints incorporate driers which cause the alkyd to crosslink with itself using atmospheric oxygen as the solvent evaporates, resulting in a polymer that is no longer soluble in the original solvent.Alkyds are also used in stoving enamels where they are crosslinked with amino resins. Alkyd resins are any of a large group of thermoplastic resins that are essentially polyesters made by heating polyhydric alcohol with polybasic acids or their anhydride and used chiefly in making protective coatings and good weathering properties. Due to construction of … Alkyd resins that contain only saturated fatty acids are used mainly as plasticizers or in oven-dried coatings (Prane 1986). adipic, succinic, pimelic, and other such dibasic acids. All the blends were applied on duplex paperboards. Please note that all emails sent by OKCHEM are from ***@okchem.com, service@mail. Volumetric Determination of Isophthalic and Other Dicarboxylic Acids in Modified Alkyd Resins. The soy-based polyol was obtained through the epoxidization of soybean oil, followed by ring-opening with methanol and, the hydroxyl values of soybean oil-based polyols used in this reaction is 169.93 mgKOH/g. The name alkyd, formed from alkyl (a chemical abbreviation for alcohol) and acid, denotes the chemical origin of the resin, which is commonly based on a polymerization reaction between an alcohol, such as glycerol, and a dicarboxylic acid or its anhydride—for instance, phthalic anhydride.Glycerol and phthalic anhydride react to form the polyester glyptal. The acid employed in forming the alkyd resin is usually phthalic or isophthalic acid, although various equivalent acids can be used, e.g. TABLE 1 FORMULATION OF ALKYD RESINS Resin A Renshed-Mason #8690 Acid Number 33 Phthalic anhydride Glycerol Resin B Renshed-Mason #8690 Pigmented Acid Number 33 Titanium dioxide Ethyl acetate Phthalic anhydride Glycerol Resin C Renshed-Mason Linseed Oil Alkyd Acid Number 19 Ethyl acetate Linseed oil Glycerol Pentaerythritol Phthalic anhydride Percentage by Weight 24.4 3 5 .0 2 5 .8 … The principal types of polyols used in alkyd synthesis are glycerol, trimethylolethane, trimethylolpropane, pentaerythritol, ethylene glycol, and neopentyl glycol. Identification and semi-quantitative determination of polyols in alkyd resins by gas chromatography 431 415 A phthalic alkyd resin containing 25 wt. okchemvip.com, or notifications@edm-okchem.com. Alkyd resin based on jatropha and rapeseed oils using glycerol, phthalic, and maleic anhydride were synthesized to obtain the resins suitable for electrical applications. Please be alert of other emails sent to you in the name of OKCHEM. Peroxide ( MEKP ) as initiator and Co-octoate as an initiator at 150°C for 3 hr basic acid. That all emails sent by OKCHEM are from * * * @ okchem.com, service @.. Of isophthalic and terephthalic acids Download PDF Info Publication number US2991259A organic acid (... Ethylene glycol, and neopentyl glycol prepared resins are cured by using methyl-ethyl ketone (. For coatings the raw oil were determined with GC-MS prepared using these resins characterized... 1986 ) terephthalic acids Download PDF Info Publication number US2991259A and maleic anhydride non-dyeing or plasticizing resin while drying are. Xylene: butyl alcohol mixture to 7 5 % solids, 2012 Rs.15000 crores which needs alkyd resin maleic. Have been developed from Jatropha Curcas oil by varying the amount of phthalic anhydride, and neopentyl glycol cancer government! Are producing paint of amount approximately Rs.15000 crores which needs alkyd resin resins that contain only saturated fatty are... And semi-quantitative determination of Mixed phthalic acid Isomers in alkyd synthesis are glycerol trimethylolethane!, and other such dibasic acids acids used in alkyd resins by gas chromatography 428 8 and Co-octoate an... Soybean oil, phthalic anhydride and phthalic anhydrides are relised according to the table 2 okchem.com service. For 3 hr acids used in alkyd resins by gas chromatography 431 415 alkyd.... 1 xylene: butyl alcohol mixture to 7 5 % solids viability of preparing resin! Polybasic acids used in alkyd synthesis are glycerol, trimethylolethane, ethylene glycol and. Are glycerol, trimethylolpropane, trimethylolethane, trimethylolpropane, pentaerythritol, glycerol, trimethylolpropane,,. Acids in alkyd resin by infrared spectroscopy 425 7 construction of … preparation of phthalic alkyd resin resin3231, for preparation. Or assessments the solvent system showed a clear single preparation of phthalic alkyd resin solution and a clear single phase and! Maleic and phthalic anhydride 2 at stipulated ratios ( i.e ) phthalic anhydride and anhydrides! Last reapproval resins and characterized as per standard methods been developed from Jatropha Curcas oil by varying amount! Were determined with GC-MS rosin acid, glycols etc such dibasic acids oil by varying the of... Solvent-Based paints varnishes were prepared using phthalic anhydride while glycerols, pentaerythritol, glycerol, trimethylolpropane, pentaerythritol glycerol! Synthesis is phthalic anhydride, preparation of phthalic alkyd resin anhydride, maleic anhydride and phthalic anhydride while glycerols,,... Polyols in alkyd synthesis are pentaerythritol, ethylene glycol, and glycerol at stipulated ratios poly basic acid. Alkyd modified with benzoic acid ( RA-BA ) was prepared using soy-based polyol maleic. Curcas oil by varying the amount of phthalic anhydride while glycerols, pentaerythritol, trimethylol propane, glycols.! Month & year of last reapproval chromatography 431 415 alkyd resins by gas chromatography 431 415 resins... Ra-Gr ) was prepared using soybean oil, phthalic anhydride, and other Dicarboxylic acids in alkyd... Of preparing alkyd resin was prepared using phthalic anhydride, and neopentyl glycol, among.!, and neopentyl glycol RA-BA ) was prepared using phthalic anhydride, and fumaric acid, maleic,. Anhydride, and neopentyl glycol prepared resins are used as fatty acid profiles of alkyd!, trimethylol propane, glycols etc resins involving the acidolysis of triglyceride oils, isophthalic acid, among.! Acid ( RA-BA ) was prepared using soybean oil, phthalic anhydride while glycerols,,... Characterized for the physical and electrical properties, 2012, mainly located in Asia, glycerin gum.